COMBUSTION CHARACTERISTICS OF DIESEL ENGINE OPERATING ON JATROPHA OIL METHYL ESTER

Abstract

Fuel crisis because of dramatic increase in vehicular population and environmental concerns have renewed interest of scientific community to look for alternative fuels of bio-origin such as vegetable oils. Vegetable oils can be produced from forests, vegetable oil crops, and oil bearing biomass materials. Non-edible vegetable oils such as jatropha oil, linseed oil, mahua oil, rice bran oil, karanji oil, etc., are potentially effective diesel substitute. Vegetable oils have reasonable energy content. Biodiesel can be used in its pure form or can be blended with diesel to form different blends. It can be used in diesel engines with very little or no engine modifications. This is because it has combustion characteristics similar to petroleum diesel. The current paper reports a study carried out to investigate the combustion, performance and emission characteristics of jatropha oil methyl ester and its blend B20 (80% petroleum diesel and 20% jatropha oil methyl ester) and diesel fuel on a single-cylinder, four-stroke, direct injections, water cooled diesel engine. This study gives the comparative measures of brake thermal efficiency, brake specific energy consumption, smoke opacity, HC, NOx, ignition delay, cylinder peak pressure, and peak heat release rates. The engine performance in terms of higher thermal efficiency and lower emissions of blend B20 fuel operation was observed and compared with jatropha oil methyl ester and petroleum diesel fuel for injection timing of 20° bTDC, 23° bTDC and 26° bTDC at injection opening pressure of 220 bar.

Keywords

Dates

  • Submission Date2009-08-03
  • Revision Date2009-11-19
  • Acceptance Date2009-12-22

DOI Reference

10.2298/TSCI1004965D

References

  1. Sheehan, J., Camobreco, V., et al., An Overview of Biodiesel and Petroleum Diesel Life Cycles, Report IVREL/TP-580-24772, National Renewable Energy Laboratory press, Golden, Col., USA, 1998, pp. 329-387
  2. Srivastava, A., Prasad, R., Triglycerides-Based Diesel Fuels, International Journal in Renewable and Sustainable Energy Reviews, 4 (2000), pp. 111-133
  3. Vellguth, G., Performance of Vegetable Oils and their Monoesters as Fuels for Diesel Engines, SAE paper 831358, 1983
  4. Demirbas, A., Biodiesel Production from Vegetable Oils via Catalytic and Non-Catalytic Supercritical Methanol Transesterification Methods, Progress in Energy and Combustion Science, 31 (2005), 5-6, pp. 466-487
  5. Jajoo, B. N., Keoti, R. S., Evaluation of Vegetable Oils as Supplementary Fuels for Diesel Engines, in: Proceedings, XV National Conference on I. C. Engines and Combustion, Anna University, Chennai, India, 1997, pp. 97-109
  6. Recep, A., Selim, C., Huseyin, S. Y., The Potential of Using Vegetable Oil Fuels as Fuel for Diesel Engines, Energy Conversion and Management, 42 (2000), 5, pp. 529-538
  7. Pramanik, K., Properties and Use of Jatropha Curcas Oil and Diesel Fuel Blends in Compression Ignition Engine, Journal of Renewable Energy, 28 (2003), 2, pp. 239-248
  8. Nabi, N., et al., Improvement of Engine Emissions with Conventional Diesel Biodiesel Blends, Bioresource Technology, 97 ( 2006), 3, pp. 372-380
  9. Agarwal, D., Agarwal, A. K., Performance and Emission Characteristics of a Jatropha Oil (Preheated and Blends) in a Direct Injection Compression Ignition Engine, Applied Thermal Engg., 27 (2007), 13, pp. 314-323
  10. Zhang, H., Wang, J., Oil from Biomass Corncob Tar as a Fuel, Energy Conversion and Management - Bioresource Technology, 48 (2007), 5, pp. 1751-1757
  11. Radhwan, M. S, et al., Jojoba Methyl Ester as a Diesel Fuel Substitute: Preparation and Characterization, Applied Thermal Engg, 27 (2007), 2-3, pp. 314-322
  12. Scholl, K. W., Sorenson, S. C., Combustion Analysis of Soyabean Oil Methyl Ester in a Direct Injection Diesel Engine, SAE paper 930934, 1993
  13. Carmen, S., Vinatoru, M., Maeda, Y.. Aspects of Ultrasonically Assisted Transesterification of Various Vegetable Oils with Methano, Ultrason Sonochem, 14 (2007), 3, pp. 380-386
  14. Nwafor, O. M. I., Effect of Advanced Injection Timing on the Performance of Rapeseed Oil in Diesel Engines, Renewable Energy, 21 (2000), 3-4, pp. 433-444
  15. Nwafor, O. M. I., The Effect of Elevated Fuel Inlet Temperature on Performance of Diesel Engine Running on Neat Vegetable Oil at Constant Speed Conditions, Renewable Energy, 28 (2003), 2, pp. 171-181
  16. Barsic, N. J., Humke, A. C., Performance and Emission Characteristics of a Naturally Aspirated Diesel Engine with Vegetable Oil Fuels, SAE paper 810262, 1981, pp. 95-109
  17. Agarwal, A. K., Biofuels (Alcohols and Biodiesel) Applications as Fuels for Internal Combustion Engines, Progress in Energy and Combustion Science, 33 (2007), 3, pp. 233-271
  18. Barnwal, B. K., Sharma, M. P., Prospects of Biodiesel Production from Vegetable Oils in India, Renewable and Sustainable Energy Reviews, 9 (2005), 4, pp. 363-378
Volume 14, Issue 4, Pages965 -977