JATROPHA OIL METHYL ESTER AND ITS BLENDS USED AS AN ALTERNATIVE FUEL IN DIESEL ENGINE

Abstract

Biomass derived vegetable oils are quite promising alternative fuels for agricultural diesel engines. Use of vegetable oils in diesel engines leads to slightly inferior performance and higher smoke emissions due to their high viscosity. The performance of vegetable oils can be improved by modifying them through the transesterification process. In this present work, the performance of single cylinder water-cooled diesel engine using methyl ester of jatropha oil as the fuel was evaluated for its performance and exhaust emissions. The fuel properties of biodiesel such as kinematic viscosity, calorific value, flash point, carbon residue, and specific gravity were found. Results indicate that B25 has closer performance to diesel and B100 has lower brake thermal efficiency mainly due to its high viscosity compared to diesel. The brake thermal efficiency for biodiesel and its blends was found to be slightly higher than that of diesel fuel at tested load conditions and there was no difference of efficiency between the biodiesel and its blended fuels. For jatropha biodiesel and its blended fuels, the exhaust gas temperature increased with the increase of power and amount of biodiesel. However, its diesel blends showed reasonable efficiency, lower smoke, and CO2 and CO emissions.

Keywords

Dates

  • Submission Date2008-12-13
  • Revision Date2009-03-11
  • Acceptance Date2009-07-12

DOI Reference

10.2298/TSCI0903207Y

References

  1. Barnwal S., Prospects of iBodiesel Production from Vegetable Oils in India, Renewable and Sustainable Energy Reviews, 9 (2005), pp. 363-378
  2. Vijaya Raju, N., Amba Prasad Rao, G., Rama Mohan, P., Esterified Jatropha Oil in Diesel Engines, Proceedings, Sixteenth National Conference on IC engines and Combustion, Jadavpur University, Calcutta, India, 2000, pp. 20-26
  3. Altõn R., An Experimental Investigation on Use of Vegetable Oils as Diesel Engine Fuels, Ph. D. thesis, Institute of Science and Technology, Gazi University, Turkey, 1998
  4. Canakci, M., Van Gerpen, J. H., Biodiesel Production from Oils and Fats with High Free Fatty Acids, Trans. of ASAE, 44 (2001), 6, pp.1429-1436
  5. Sarin, R., Sharma, M., Jatropha Palm Biodiesel Blends: An Optimum Mix for Asia, Fuel, 86 (2007), 10, pp. 1365-1371
  6. Forson, F. K., Oduro, E. K., Hammond-Donkoh, E., Performance of Jatropha Oil Blends in a Diesel Engine, Renewable Energy, 29 (2004), 7, pp. 1135-1145
  7. Pramanik, K., Properties and Use of Jatropha Curcas Oil and Diesel Fuel Blends in Compression Ignition Engine, Renewable Energy, 28 (2003), 2, pp. 239-248
  8. Pradeep, V., Sharma, R. P., Use of Hot EGR for NOx Control in a Compression Ignition Engine Fueled with Biodiesel from Jatropha Oil, Renewable Energy, 32 (2006), pp. 1136-1154
  9. Agarwal, D. A., Agarwal, A. K., Performance and Emission Characteristics of Jatropha Oil (Preheated and Blends) in a Direct Injection Compression Ignition Engine, Applied Thermal Engineering, 27 (2007), pp. 2314-2323
  10. Varaprasad, C. M., Murali Krishna, M. V. S., Prabhakar Reddy, C., Investigations on Biodiesel (Esterified Jatropha Curcas Oil) in Diesel Engines, XV National Conference on IC Engines and Combustion, Anna University, Chennai, India, 1997
  11. Agarwal, D., Kumar, L., Agarwal, A. K., Performance Evaluation of a Vegetable Oil Fuelled Compression Ignition Engine, Renewable Energy, 33 (2008), 6, pp. 1147-1156
  12. Forgiel, R., Varde, K. S., Experimental Investigation of Vegetable Oil Utilization in a Direct Injection Diesel Engine, SAE Alternate Fuels for Diesel Engines, SP 500 Fuels and Lubricants Meeting, Tulsa, Okla., USA, 1981, SAE paper
  13. Harrington, K. J, Chemical and Physical Properties of Vegetable Oil Esters and Their Effect on Diesel Fuel Performance, Biomass, 9 (1986), 1, pp. 1-17
  14. Yukitsugu, I., Takeuchi, R., Transesterified Curcas Oil Blend for Farm Diesel Engines, Trans. of ASAE, 30 (1987), 3, pp. 605-609
  15. Patil, V., Singh, K., Oil Gloom to Oil Boom. Jatropha Curcas a Promising Agroforestry Crop. Shree Offset Press, Nashik, India, 1991
  16. I. S. I, Methods of Test for Internal Combustion Engines, IS: 10000 Part I-XII. Indian Standards Institute, New Delhi, 1980
  17. Ali, Y., Hanna, M. A., Alternative Diesel Fuels from Vegetable Oils, Bioresource Technology, 50 (1994), 2, pp. 153-163
  18. Yamane, K., Ueta, A., Shimamoto, Y., Influence of Physical and Chemical Properties of Biodiesel Fuels on Injection, Combustion and Exhaust Emission Characteristics in a Direct Injection Compression Ignition Engine, International Journal of Engine Research, 2 (2001), 4, pp. 249-261
  19. Takeda, Y., Development Study Jatropha Curcas (Sabu Dum) Oil as a Substitute for Diesel Engine Oil in Thailand, Journal of Agricultural Association of China, 120 (1982), 10, pp. 1-8
  20. Senthil Kumar, M., Ramesh, A., Nagalingam, B., An Experimental Comparison of Methods to Use Methanol and Jatropha Oil in a Compression Ignition Engine, Biomass and Bioenergy Journal, 25 (2003), 3, pp. 309-318
Volume 13, Issue 3, Pages207 -217